Following a catalyst regeneration a fire occurred on a hydrocracking unit during unit pressure testing prior to start-up. The fire resulted from ignition of high - pressure hydrogen-rich gas that…
The leak ignited at the seal located between the bottom and the body of a heat exchanger of a desulfurization unit of a refinery. The fire is alimented by the leaking fuel under pressure for about…
Hydrogen ignition during welding on a VSC-24 spent fuel cask Pursuant to 10 CFR 72.210 - fuel in an independent spent fuel storage installation at its Point Beach Nuclear Power Plant. The inspection…
The fire, 1 m high fire occurred in a pipe at the inlet of the hydrodesulfurisation unit of a refinery. The fire was caused by the leak of the pipe content, hydrogen and diesel fuel. According to the…
Collision of a hydrogen and fuel cells bus.The bus driver took the curve too narrow and hit the corner of the overhang of a shop. The bus was damaged at the upper right corner.
Collision of a hydrogen and fuel cells bus with private car. The driver of the private car parked nearby a hospital opened the driver door. Damage at the front, right side, body and windowpane.
A hydrogen and fuel cells bus was hit by a car. Damage on the right side
A hydrogen and fuel cells bus was hit by another bus at the bus stop, damaging the rear, left side.
A fire, fuelled by a mixture of gasoline and hydrogen, occurred on a heat exchanger located at 15 m height in a gasoline processing unit of a refinery. The operator triggered the emergency plan. Site…
Spillage of hydrogen and heavy gas oil at heavy oil hydrogenation desulfurization device due to insufficient heat treatment after welding valve:
In a petrochemical plant, a gas mixture at 270 bar made of 75% hydrogen (H2) and 25% methane (CH4) leaked through the bottom valve of a dryer of a resin production unit. After detection of the leak,…
An explosion occurred while inflating a balloon with hydrogen gas. The News reported the involvement of the hydrogen bottle.
An accident occurred prior to the performance of a hydrogen-oxygen balloon demonstration, seriously injuring the demonstrator, who suffered painful second-degree burns to his right forearm and had to…
The hydrogen possible leaked and ignited from a tank which was inside a car parked in a hospital underground parking garage. The tank was supposed to be used for launching a weather balloon. Two…
Since the release could not be stopped by intervening at the leaking point, the fire brigade decided to vent the whole content of the pallet (246 m3) by gradually opening the valves and by keeping…
Hydrogen bus hit by a private car, which was driving out from a parking place. Bus damaged on the rear, right side.
Hydrogen bus hit by a car during the turn to the left; bus left side damaged.
hydrogen bus hit by a car. Damage on the bus right side.
Hydrogen bus hit by private car in the roundabout at the main station; damage on the right side
A hydrogen car caught fire at a hydrogen fuelling station. During refuelling of a H2-fueled car the owner heard an abnormal noise and opened the fuel filler door to investigate. A small fire then…
An explosion and fire occurred at a reciprocating recycle hydrogen compressor during commissioning of a new Diesel hydrotreatement Unit. It happened during the reactor pre-sulphidisation step, when…
An explosion occurred in hydrogen compressor, due to rupture of 4 inch suction pipeline to the compressor. "Hydrogen...exploded and continued to burn until it was extinguished".3 fatalities.
[NOTE: the sources are not completely clear in describing the system involved in this incident ; the following is the most plausible option according to HIAD validator]The explosion happened in two…
A huge car crash take place on the highway A4/E70 between Padua and Trieste, North of Italy. More than 250 cars were involved. More than 13 persons died and more than 90 injured. The main reason of…
A shift supervisor received severe burns and later died after a flexible hose used to transfer hydrogen to the catalytic reformer was over-pressurised and caught fire.Hydrogen is supplied from three…
Hydrogen explosion at a chlorine chemical production plant (Seveso-classified) The plant had been shut down for two weeks, and maintenance works were ongoing. Two subcontractor employees were…
The accident occurred at a distillate dewaxing Unit (MDDW) of the refinery, during the operation of regeneration of the catalyst. To perform this operation, both temperature and pressure have to be…
Maintenance works were ongoing after an outage at a turbine and generator unit of the plant. Fifteen maintenance mechanics were working at that time on the unit. An access cover was removed causing…
The event occurred in a support building at a test stand complex. The explosion destroyed two support buildings and severely damaged a large amount of equipment. No one was injured.Gaseous hydrogen…
A hydrogen leak followed by an explosion occurred at an elbow of a pipeline cooling system and the separator of the distillation unit. The explosion destroyed the unit and injured two workers.
